Service - an investment!

An investment which will pay dividends in the form of improved reliability, durability, and resale value.

8:2	Label Information
8:3	Maintenance service, Warranty
8:4	Maintenance schedule
8:6	Engine oil
8:8	Exhaust Emission Service
8:13	Engine compartment
8:14	Lubrication, body
8:15	Power steering fluid, brake fluid
8:16	Drive belt
8:17	Cooling system

1 Vehicle Identification Number (VIN) *

VIN plate is located on top left surface of dashboard. The VIN is also stamped on the right hand door pillar.

2 Vehicle Emission Control Information

Your Volvo is designed to meet all applicable emissions standards, as evidenced by the certification label on the right side of the firewall. For further information regarding these regulations, please consult your Volvo dealer.

3 Model Plate

Vehicle Identification Number (VIN). Codes for color and upholstery etc.. This plate is located on panel-above right headlight.

4 Loads and Tire Pressures

5 Federal Motor Vehicle Safety Standards (FMVSS) specifications (USA) and Ministry of Transport (CMVSS) Standards (Canada)

Your Volvo is designed to meet all applicable safety standards, as evidenced by the certification label on the rear facing side of the driver's door. For further information regarding these regulations, please consult your Volvo dealer.

* The Vehicle Identification Number (VIN) should always be quoted in all correspondence concerning your vehicle with the retailer and when ordering parts.

All specifications are subject to change without notice.

Maintenance service at 10,000 mile (16,000 km) intervals

Volvo advises you to follow the service program at 10,000 mile (16,000 km) intervals which is outlined in the "Maintenance Records Manual". This maintenance program contains inspections and services necessary for the proper function of your car over the next 10,000 miles (16,000 km).
The maintenance services contain several checks which require special instruments and tools and therefore must be performed by a qualified technician.
To keep your Volvo in top condition, specify time tested and proven Genuine Volvo Parts and Accessories.

The Federal Clean Air Act - U.S.

The Clean Air Act requires vehicle manufacturers to furnish written instructions to the ultimate purchaser to assure the proper functioning of those components that control emissions.
The maintenance instructions listed in the "Servicing" section of this Manual represent the minimum maintenance required. These services are not covered by the warranty. You will be required to pay for labor and material used. Refer to your Warranty booklet for further details.

Maintenance services

Your Volvo has passed several major inspections before being delivered to you, according to Volvo specifications. The maintenance services outlined in this book should be performed as indicated. The extended maintenance service intervals make it even more advisable to follow this program. Inspection and service should also be performed any time a malfunction is observed or suspected.
It is recommended that receipts for vehicle emission services be retained in the event that questions arise concerning maintenance. See your "Maintenance Records Manual".

Applicable warranties - U.S.

In accordance with U.S. Federal Regulations, the following list of applicable U.S. warranties is provided. For Canadian specification vehicles, see your separate warranty booklet.

Emission Performance Warranty

These are the Federal warranties; other warranties are provided as required by state law.

Refer to your separate Warranty booklet for detailed information concerning each of the warranties.

pg. 8:4 Maintenance schedule

Maintenance schedule

A = Adjust (Correct if necessary) I = Inspect (Correct or Replace if necessary)
R = Replace L = Lubricate

Maintenance Operation
thousand miles					5	10	20	30	40	50	60
(thousand km)					(8)	(16)	(32)	(48)	(64)	(80)	(96)
EMISSIONS SYSTEM MAINTENANCE
Engine Oil and Oil filter					R	R	R	R	R	R	R
Engine Drive Belt											R
Air Cleaner Filter								R			R
Spark Plugs								R			R
Automatic Transmission fluid						I	I	I	I	I	I
Rear Axle Oil						I	I	I	I	I	I
Timing belt - B 6304 F										R

1) See section "Engine oil" for detailed information.
2) For services beyond 60,000 miles (96,000 km), consult your "Maintenance records booklet".
3) No cost to the owner.

pg. 8:5 Maintenance schedule

Maintenance Operation thousand miles (thousand km)	10 (16)	20 (32)	30 (48)	40 (64)	50 (80)	60 (96)
MISCELLANEOUS MAINTENANCE
ENGINE
Fuel (Line) Filter
PCV Nipple (Orifice)/hoses,clean						I
Battery Charge		I		I		I
EGR valve, clean						I
BRAKES
Inspect Brakes, Replace components as necessary	I	I	I	I	I	I
Brake Fluid			R			R
STEERING
Rotate tires/check tire wear; (Align if needed.)	I	I	I	I	I	I
Check power steering fluid level.	I	I	I	I	I	I
BODY
Power antenna (clean)	I	I	I	I	I	I
Trunk, Hood Hinges and Latches	L	L	L	L	L	L
Sun roof	L	L	L	L	L	L

The following items should be checked weekly by the driver (it takes only a few minutes):
Engine oil level Windshield wipers Cleaning
Brake fluid level Level of windshield washer fluid Rust protection
Radiator coolant level The following should also be carried out at
Tire pressure (all five tires) regular intervals:
Operation of all lights Washing
Horns Polishing

---

  
Contents | Top of Page